Skip to main content
  • Research article
  • Open access
  • Published:

The non-metabolizable glucose analog D-glucal inhibits aflatoxin biosynthesis and promotes kojic acid production in Aspergillus flavus

Abstract

Background

Aflatoxins (AFs) are potent carcinogenic compounds produced by several Aspergillus species, which pose serious threats to human health. As sugar is a preferred carbohydrate source for AF production, we examined the possibility of using sugar analogs to inhibit AF biosynthesis.

Results

We showed that although D-glucal cannot be utilized by A. flavus as the sole carbohydrate source, it inhibited AF biosynthesis and promoted kojic acid production without affecting mycelial growth when applied to a glucose-containing medium. The inhibition occurred before the production of the first stable intermediate, norsolorinic acid, suggesting a complete inhibition of the AF biosynthetic pathway. Further studies showed that exogenous D-glucal in culture led to reduced accumulation of tricarboxylic acid (TCA) cycle intermediates and reduced glucose consumption, indicating that glycolysis is inhibited. Expression analyses revealed that D-glucal suppressed the expression of AF biosynthetic genes but promoted the expression of kojic acid biosynthetic genes.

Conclusions

D-glucal as a non-metabolizable glucose analog inhibits the AF biosynthesis pathway by suppressing the expression of AF biosynthetic genes. The inhibition may occur either directly through interfering with glycolysis, or indirectly through reduced oxidative stresses from kojic acid biosynthesis.

Background

Aflatoxins (AFs) are highly carcinogenic secondary metabolites produced by Aspergillus species such as A. flavus and A. parasiticus after invading plants or stored grains. Contaminations of these toxins in the food chain pose serious threats to humans and animals [1, 2]. Previous studies focused on understanding the molecular machinery of AF biosynthesis [3], which have shown that most genes involved in the production of AF are located in a co-regulated gene cluster that encodes two regulatory proteins (aflR and aflS) and at least 26 down-stream metabolic enzymes [4]. An independently regulated sugar utilization gene cluster is located adjacently [5].

Some environmental factors and chemical reagents are known to be able to inhibit AF production [6, 7]. Sugar is the most frequently used carbohydrate for studying AF production [8]. It has been proposed that the key factor determining if a carbohydrate supports AF production is its metabolic availability to the hexose monophosphate shunt and glycolysis pathway [9]. We thus speculate that sugar analogs that are unable to be utilized by A. flavus are candidate inhibitors for AF biosynthesis. Chemical analogs are often used to inhibit metabolism, as they may bind competitively to the active or allosteric sites of enzymes and hamper their activities [10, 11]. Three glucose analogs, 2-deoxyglucose, α-methyglucoside and glucosamine, have been tested in A. parasiticus previously, but none of them inhibited AF production when applied to a glucose-containing medium [12].

D-glucal and D-galactal are cyclic enol ether derivatives of glucose and galactose, respectively (Additional file 1). In this study we examined in A. flavus for their effects on AF biosynthesis. It has been reported that D-glucal inhibits glucose oxidase (EC 1.1.3.4) [13–15], while D-galactal inhibits β-D-galactopyranosidase (EC 3.2.1.23) [16]. Whether these compounds have any effects on glycolysis and/or AF biosynthesis is not known. Results obtained in this study showed that D-glucal, but not D-galactal, is able to inhibit AF biosynthesis and to enhance kojic acid biosynthesis without affecting mycelial growth. The inhibition occurred before the production of norsolorinic acid (NOR), the first stable intermediate in the AF biosynthetic pathway. Metabolomics studies suggested that the glycolysis pathway was inhibited in mycelia grown in the presence of D-glucal. Using quantitative reverse transcription-PCR (qRT-PCR), we showed that exogenous D-glucal suppressed expression of AF biosynthetic genes tested but enhanced expression of kojic acid biosynthetic genes.

Results

Use of D-glucal and D-galactal as the sole carbohydrate source did not support mycelial growth

The usual GMS medium used for culturing A. flavus contains 50 mg/mL glucose [17]. To examine if D-glucal and D-galactal could be used as the sole carbohydrate for mycelial growth, we replaced the glucose in the medium with 20 or 40 mg/mL D-glucal or D-galactal. Media containing either 20 or 40 mg/mL D-glucose were used as the control. After incubation of A. flavus A 3.2890 spores in these media for 3 d, we observed no mycelial growth in media with D-glucal or D-galactal, while abundant mycelial growth was observed in those two controls (Figure 1). No further growth was observed in media with D-glucal or D-galactal even when the incubation period was extended to 10 d, suggesting neither these two sugar analogs support mycelial growth when used as the sole carbohydrate.

Figure 1
figure 1

D-glucal or D-galactal as the sole carbohydrate source did not support mycelial growth. A. flavus cultured for 3 d in GMS media in which glucose was replaced by 20 or 40 mg/mL D-glucal or D-galactal. GMS media containing 20 or 40 mg/mL D-glucose were used as controls. No visible mycelial growth was observed in D-glucal- or D-galactal-containing media.

D-glucal inhibited AF biosynthesis and sporulation without affecting mycelial growth in GMS media

To test whether D-glucal or D-galactal inhibit AF biosynthesis, spores of A. flavus A 3.2890 were inoculated in GMS liquid media (containing 50 mg/mL glucose) supplied with 2.5, 5, 10, 20, or 40 mg/mL of D-glucal or D-galactal and cultured at 28°C for 5 d. GMS media with the same amounts of additional D-glucose were used as controls. AFs were extracted from each sample, and the AFB1 contents were quantified using high pressure liquid chromatography (HPLC). As shown in Figure 2A, the AFB1 content was reduced significantly in samples with 2.5 to 40 mg/mL D-glucal. An almost complete inhibition was observed when 40 mg/mL D-glucal was used. In contrast, GMS media supplied with 2.5,5 or 10 mg/mL D-glucose promoted AFB1 production (Figure 2A). In samples supplied with D-galactal only a slight inhibition on AFB1 production was detected at the concentration of 40 mg/mL (Figure 2A). Using thin layer chromatography (TLC) analyses, we showed further that production of other AFs such as AFB1 and AFG1 were also inhibited by D-glucal (Figure 2B).

Figure 2
figure 2

Effects of D-glucal and D-galactal on AF production and sporulation. (A) Amounts (μg per mL media) of AFB1 produced by A. flavus with different concentrations of D-glucose, D-glucal, or D-galactal (0, 2.5, 5, 10, 20 or 40 mg/mL). Data are presented as means ± S.D. (n = 3), from 3 independent experiments. (B) TLC analyses of AF production by A. flavus cultured in GMS media with different concentrations of D-glucal (0, 2.5, 5, 10, 20 or 40 mg/mL). (C) Growth curves of mycelia cultured in media with 40 mg/mL D-glucose, D-glucal, or D-galactal for 5 d. (D) Numbers of spores produced per mL culture with D-glucose, D-glucal, or D-galactal. Data are presented as means ± S.D. (n = 3).

We next examined if D-glucal or D-galactal inhibited mycelial growth, and found that neither D-glucal nor D-galactal affected mycelial growth at the concentration of 40 mg/mL (Figure 2C). In contrast, additional D-glucose enhanced mycelial growth significantly, especially from the 3rd day onwards (Figure 2C). We next performed experiments on solid GMS media with 40 mg/mL D-glucal or D-galactal to assess if these sugar analogs have any effect on sporulation, and observed that exogenous D-glucal inhibited sporulation significantly, while additional D-glucose enhanced sporulation (Figure 2D). No effect was observed for D-galactal.

D-glucal promoted kojic acid biosynthesis, but inhibited fatty acid biosynthesis and glucose consumption

We performed metabolomics analyses of mycelia of A. flavus A 3.2890 grown in media with or without 40 mg/mL D-glucal. The gas chromatography time-of-flight mass spectrometry (GC-TOF MS) based metabolomics technology developed in our lab has been shown to be a powerful tool to elucidate metabolic changes in A. flavus[18]. For statistical analyses, we used nine replicates for each treatment. Partial least-squares (PLS) analyses of metabolite peak areas showed clustering of two distinct groups for mycelia grown in media with or without D-glucal, suggesting that exogenous D-glucal imposed significant metabolic changes in mycelia (Figure 3). In particular, in the presence of D-glucal, the content of glucose, ribitol, glycerol and galactose were increased significantly, while the content of TCA intermediates (succinic acid, malic acid and fumaric acid) and fatty acids (FAs) including palmitic acid, stearic acid, oleic acid and linoleic acid were decreased (Table 1). We also noticed that, in the presence of D-glucal, the content of two secondary metabolites, kojic acid and furanacetic acid, were increased by 2 and 159 fold, respectively. These results together suggest that D-glucal interferes with both primary and secondary metabolism.

Figure 3
figure 3

Mycelia grown in media with or without D-glucal showed significant differences in the accumulation of various metabolites. PLS analyses were performed using SIMCA-P V12.0. (A) Loadings plot obtained from PLS analyses of the entire GC-TOF MS dataset. (B) PLS scores plot of different metabolites in mycelia cultured for 5 d in GMS media with (â–²1) or without (â–²2) 40 mg/mL D-glucal, showing clear differences between these two sample groups. Nine replicates for each treatment.

Table 1 Metabolites with significant differences between mycelia of A. flavus grown in media with or without D-glucal (40 mg/mL)

We next cultured A. flavus A 3.2890 in GMS media with or without 40 mg/mL D-glucal, and measured kojic acid contents in media using a colorimetric method [19]. During the 5-d culture period the kojic acid contents in media with D-glucal were always higher (about 4 to 5 folds) than the control (Figure 4A). We also measured glucose content in the media and observed that, in the presence of D-glucal, the glucose content on the 4th and the 5th d were about 30% higher than those in the control media lacking D-glucal, suggesting that exogenous D-glucal inhibited the consumption of glucose (Figure 4B).

Figure 4
figure 4

Effects of D-glucal on kojic acid production, glucose consumption and NOR accumulation. (A) Production of kojic acid by A. flavus grown in GMS media with or without 40 mg/mL D-glucal. Values are presented as means ± S.D. (n = 3), from three independent experiments. (B) Glucose contents in media at different time points when cultured in the presence of 40 mg/mL D-glucal. (C) D-glucal inhibited NOR accumulation. The amount of NOR in GMS medium lacking D-glucal was set to 1, those in other samples were calculated accordingly. Values are presented as means ± S.D. (n = 3).

D-glucal inhibited NOR production

We used the A. flavus strain Papa 827 to decipher at which step D-glucal inhibits AF biosynthesis. The lack of functional NOR reductase in this strain results in the accumulation of the first stable compound, NOR, in the AF biosynthetic pathway [20]. NOR is pinkish in color. After 4-d cultures, the control plate was pink in color, while no color was observed in the plate with 40 mg/mL D-glucal. Spectrophotometric analyses showed that NOR productions were significantly inhibited by D-glucal at concentrations of 10 mg/mL or higher (Figure 4C). These results suggest that D-glucal inhibits the AF biosynthesis pathway prior to the production of NOR.

D-glucal inhibited expression of AF biosynthetic genes, but promoted expression of kojic acid biosynthetic genes

To examine the effect of D-glucal on AF biosynthesis at the transcriptional level, we analyzed expression of several genes in the AF biosynthetic gene cluster in A. flavus A 3.2890 by qRT-PCR and observed that, in the presence of 40 mg/mL D-glucal, no significant change was detected for aflR [a Zn (II)2 Cys6 transcription factor], while a 28% reduction was observed for aflS (a co-activator, Figure 5A). In addition, expression levels of all seven genes encoding AF biosynthetic enzymes tested, aflC (polyketide synthase), aflD (oxidoreductase), aflM (dehydrogenase), aflO (O-methyltransferase B), aflP (O-methyltransferase A), aflU (P450 monooxygenase) and nadA (a cytosolic enzyme converting AFB1 to AFG1), were decreased significantly (Figure 5A). Among these, aflC encodes an upstream enzyme in AF biosynthesis pathway, acting before NOR production to synthesize the polyketide backbone [21], while nadA encodes the most downstream enzyme, converting AFB1 to AFG1 [22, 23].

Figure 5
figure 5

Expression analyses of genes for AF and kojic acid production and sugar utilization. (A) qRT-PCR analyses of expression of 9 AF biosynthetic genes (aflR, aflS, aflC, aflD, aflM, aflP, aflO, aflU, and nadA) and 3 sugar utilization genes (hxtA, glcA and sugR) in mycelia grown with or without 40 mg/mL D-glucal for 3 d, The relative expression levels were quantified through comparison with the expression level of β-tubulin. Data are presented as means ± S.D. (n = 3). (B) Expression of 3 kojic acid biosynthetic genes (kojA, kojR, kojT) by qRT-PCR in mycelia grown with or without 40 mg/mL D-glucal for 3 d. The relative expression levels were quantified through comparison with the expression level of β-tubulin. Data are presented as means ± S.D. (n = 3).

We then examined if the expression levels of genes in the sugar utilization gene cluster were changed when cultured in media containing D-glucal. Of three genes tested, sugR (transcriptional regulator), hxtA (sugar transport), and glcA (glycosylation), none showed significant changes in expression (Figure 5A). We also analyzed the expression of genes involved in kojic acid biosynthesis: kojR [a Zn (II)2 Cys6 transcription factor], kojA (FDA-dependent oxidoreductase) and kojT (a major facilitator superfamily transporter) [24], and observed that expression levels of all these 3 genes were increased when cultured in media with 40 mg/mL D-glucal (Figure 5B).

Discussion

Sugars such as glucose and sucrose are preferred carbohydrates for growth and AF production [25]. Glucose is utilized through glycolysis and TCA cycling to provide energy and substrates for downstream metabolic pathways including the AF biosynthesis pathway [26, 27]. Glucose may also act as a signal molecule in sugar sensing to fine-tune the growth and metabolic activities based on the availability of glucose [28]. Genomic sequencing of A. flavus revealed 55 putative secondary metabolism gene clusters that are differentially regulated through global transcriptional regulators such as LaeA and VeA [2]. Individual secondary metabolic pathways may further be regulated independently by transcriptional regulators located in individual gene clusters for example, aflR and aflS in AF biosynthesis and kojR in kojic acid biosynthesis [2, 29, 30].

Non-metabolizable chemical analogs have been used in the past to inhibit metabolic pathways and to study metabolism [25]. In this study, we examined D-galactal and D-glucal, non-metabolizable chemical analogs of D-glucose and galactose, respectively, for their effects on AF biosynthesis in A. flavus. We observed that 40 mg/mL D-galactal as a galactose analog did not have much effect on AF production. This is not surprising as though galactose supports mycelial growth, it cannot be utilized efficiently for AF biosynthesis [8, 31], suggesting galactose utilization might be independent from the AF biosynthesis pathway. In contrast, 40 mg/mL D-glucal effectively inhibited AF biosynthesis. In the presence of D-glucal, glucose consumption and FA biosynthesis were reduced; the concentrations of TCA cycle intermediates were also reduced. In contrast, the production of kojic acid, a secondary metabolite produced directly from glucose, and furanacetic acid, a secondary metabolite of unknown function, were increased. At the metabolic level, we observed that D-glucal inhibited AF biosynthesis before production of the first stable intermediate, NOR. Based on these observations, we propose that, as depicted in route â‘  of Figure 6, D-glucal may interfere directly with enzymes such as hexokinase in glycolysis to prevent sufficient acetyl-CoA to be produced for TCA cycling, and for AF and FA biosynthesis in A. flavus. Consequently this has led to the increased glucose level observed in media and possibly in mycelia as well, which may enhance kojic acid biosynthesis. This hypothesis is in agreement with some previous observations that showed that active AF production usually correlates with increased accumulation of TCA cycle intermediates and active FA biosynthesis [26, 32, 33].

Figure 6
figure 6

A working model of D-glucal in inhibiting AF production. A hypothetical model showing possible roles of D-glucal in inhibiting AF production. Routes â‘  and â‘¡ depict two possible modes of actions. For further explanations, see the Discussion.

Alternatively, since kojic acid is synthesized from glucose without going through glycolysis [34], exogenous D-glucal may interfere with the sugar sensing machinery to enhance kojic acid production directly. The accumulation of kojic acid may have then relieved the oxidative stress in the fungus, which consequently inhibits AF biosynthesis at the transcriptional level, as depicted in route ② of Figure 6. It is known that kojic acid is a potent antioxidant that is able to scavenge reactive oxygen species [35], and oxidative stress is a prerequisite for AF production [36]. As reported previously, antioxidants such as eugenol, saffron and caffeic acid are able to inhibit AF biosynthesis [37–39]. A negative correlation between kojic acid and AF production has been shown before. D-xylose, ethanol, Dioctatin A and high temperature are factors known to promote kojic acid production, but inhibit AF biosynthesis [40, 41].

We also showed that, although neither D-glucal nor D-galactal supported mycelial growth when used as the sole carbohydrate source, D-glucal inhibited sporulation without affecting mycelial growth. Secondary metabolism is usually associated with sporulation in fungi [42], a G-protein signaling pathway is involved in coupling these two processes [43, 44]. The coupling does not seem to be very tight, as molasses promotes sporulation but suppresses AF production in Aspergillus flavus[45]. It will be interesting to study if D-glucal acts independently in AF production and sporulation, or if a common signaling pathway is involved in both processes.

Conclusions

We showed in this study that D-glucal effectively inhibited AF biosynthesis and promoted kojic acid biosynthesis through modulating expression of genes in these two secondary metabolic pathways. The inhibition may occur either directly through interfering with glycolysis, or indirectly through reduced oxidative stresses from kojic acid biosynthesis.

Methods

Fungal strains and culture conditions

A. flavus A3.2890 was obtained from the China General Microbiological Culture Collection Center, Institute of Microbiology, Chinese Academy of Sciences. A. flavus Papa 827 was provided by Gary Payne [20]. All strains were maintained in glycerol stocks and grown on potato dextrose agar (PDA) medium at 37°C for 4 d before spores were collected to initiate new cultures. The PDA medium was also used for the examination of NOR accumulation. For all other experiments, Adye and Mateles’ GMS medium was used (containing 5% glucose) [17]. D-glucal and D-galactal were purchased from Chemsynlab (Beijing, China). AF standards were purchased from Sigma (St. Louis, USA).

Determination of fungal dry weights

Mycelia cultured for 2, 3, 4 and 5 days were harvested by filtration through two layers of filter paper, washed by sterilized water, and freeze-dried before weighing.

AF extractions and analyses

Mycelia grown in 1 mL GMS media were extracted using 1 mL chloroform/water (1:1). After vortexing for 2 min, the mixture was centrifuged at 12,000 rpm for 10 min. The organic phase was then collected and filtered through a 0.22 Î¼m filter, dried under nitrogen gas, and re-dissolved in 200 Î¼L chloroform before being analyzed by TLC as described previously [18]. The AFB1 content was measured by HPLC (Agilent 1200, Waldbronn, Germany) using a reverse phase C18 column (150 mm in length and 4.6 mm in internal diameter, 5 Î¼m particle size, Agilent), eluted initially with 25% methanol/20% acetonitrile water solution for 3 min, and then with 38% methanol for 2.9 min, detected by a DAD analyzer at 360 nm. Quantifications were performed by measuring peak areas and comparing with an AFB1 standard calibration curve.

Spore counting

Three mL of sterile water with 0.05% Tween-20 was added to the surface of PDA plates on which A. flavus were grown for 3 d. Spores were scraped with a cell scraper before being counted with a haemacytometer.

qRT-PCR

Mycelia grown in GMS media with or without 40 mg/mL D-glucal for 3 d were collected and ground in liquid nitrogen, and total RNA was extracted using a Trizol solution (Invitrogen, CA, USA). PolyA mRNA was purified from mycelia with the PolyAT Rack mRNA isolation system (Promega, Madison, WI). Template cDNA was synthesized by reverse transcription with ReverTra Ace-α-® (Toyobo, Japan) at 42°C for 1 h, followed by incubation at 85°C for 15 min to terminate the reaction. qRT-PCR was performed using SYBR Green I (Takara, Japan) and a Rotor-Gene 3000 (Corbett, Australia) with primers described in Additional file 2: Table S1. PCR programs used are 94°C for 30 sec, 40 cycles at 94°C for 30 sec, followed by annealing (55°C for aflO, aflR, aflS, aflD and β-tubulin; 62.5°C for aflU and nadA; 58°C for kojA, kojR and kojT; 61°C for hxtA, glcA and sugR; 60°C for aflC, aflM and aflP) for 30 sec, and 72°C for 30 sec. The relative expression levels were quantified by comparing the expression level of β-tubulin.

Kojic acid and glucose measurements

A. flavus A3.2890 was cultured in a GMS liquid medium plus 40 mg/mL D-glucal for 5 d. Media samples were harvested by centrifugation at 12,000 rpm for 10 min before kojic acid was quantified according to Bentley [19]. Glucose contents in media were measured by using a glucose determination kit (Applygen, Beijing). The absorbance was measured at 550 nm using a multimode plate reader (Tecan Infinite M200 PRO, Switzerland), and calculated against a glucose standard curve.

Metabolomics analyses

Metabolites in mycelia of A. flavus A3.2890 cultured in a GMS liquid medium with or without 40 mg/mL D-glucal for 5 d were purified, silyl-derivatized and analyzed with GC-TOF MS as described previously [18], with minor modifications. The column temperature was held at 100°C for 3 min, and raised to 150°C at a rate of 10°C/min, then to 250°C at 5°C/min, finally to 300°C at 10°C/min, and held for 15 min at 300°C. PLS analysis was performed using SIMCA-P V12.0 (Umetrics, Sweden).

NOR analyses

A. flavus Papa 827 was cultured for 4 d on PDA media containing 0, 5, 10, 20, or 40 mg/mL D-glucal. Quantification of NOR was performed as reported [46] with modifications. Briefly, media samples were mixed with 0.5 mL 90:10 methanol/1 N NaOH (pH 10). NOR is pinkish at this pH, which allows for spectrophotometric measurement at 595 nm with a 96-well Tecan plate reader.

Statistical analyses

All experiments were conducted with at least 3 replicates and statistical significance was evaluated using Student’s t-tests.

References

  1. Yu J, Cleveland TE, Nierman WC, Bennett JW: Aspergillus flavus genomics: gateway to human and animal health, food safety, and crop resistance to diseases. Rev Iberoam Micol. 2005, 22 (4): 194-202. 10.1016/S1130-1406(05)70043-7.

    PubMed  Google Scholar 

  2. Amaike S, Keller NP:Aspergillus flavus. Annu Rev Phytopathol. 2011, 49: 107-133. 10.1146/annurev-phyto-072910-095221.

    CAS  PubMed  Google Scholar 

  3. Roze LV, Hong SY, Linz JE: Aflatoxin biosynthesis: current frontiers. Annu Rev Food Sci Technol. 2013, 4: 293-311. 10.1146/annurev-food-083012-123702.

    CAS  PubMed  Google Scholar 

  4. Cleveland TE, Yu J, Fedorova N, Bhatnagar D, Payne GA, Nierman WC, Bennett JW: Potential of Aspergillus flavus genomics for applications in biotechnology. Trends Biotechnol. 2009, 27 (3): 151-157. 10.1016/j.tibtech.2008.11.008.

    CAS  PubMed  Google Scholar 

  5. Yu J, Chang P, Bhatnagar D, Cleveland TE: Cloning of a sugar utilization gene cluster in Aspergillus parasiticus. Biochim Biophys Acta. 2000, 1493 (1–2): 211-214.

    CAS  PubMed  Google Scholar 

  6. Holmes RA, Boston RS, Payne GA: Diverse inhibitors of aflatoxin biosynthesis. Appl Microbiol Biotechnol. 2008, 78 (4): 559-572. 10.1007/s00253-008-1362-0.

    CAS  PubMed  Google Scholar 

  7. Gupta SR, Prasanna HR, Viswanathan L, Venkitasubramanian TA: Effect of some inhibitors on aflatoxin-production in a synthetic medium and on the incorporation of acetate-1–14C into aflatoxins by resting mycelia of Aspergillus parasiticus. Bull Environ Contam Toxicol. 1976, 15 (4): 447-453. 10.1007/BF01685070.

    CAS  PubMed  Google Scholar 

  8. Davis ND, Diener UL, Agnihotr VP: Production of aflatoxins B1 and G1 in chemically defined medium. Mycopathol Mycol Appl. 1967, 31 (3–4): 251-256.

    CAS  PubMed  Google Scholar 

  9. Davis ND, Diener UL: Growth and aflatoxin production by Aspergillus parasiticus from various carbon sources. Appl Microbiol. 1968, 16 (1): 158-159.

    PubMed Central  CAS  PubMed  Google Scholar 

  10. Gloster TM, Zandberg WF, Heinonen JE, Shen DL, Deng L, Vocadlo DJ: Hijacking a biosynthetic pathway yields a glycosyltransferase inhibitor within cells. Nat Chem Biol. 2011, 7 (3): 174-181. 10.1038/nchembio.520.

    PubMed Central  CAS  PubMed  Google Scholar 

  11. Araujo WL, Trofimova L, Mkrtchyan G, Steinhauser D, Krall L, Graf A, Fernie AR, Bunik VI: On the role of the mitochondrial 2-oxoglutarate dehydrogenase complex in amino acid metabolism. Amino Acids. 2013, 44 (2): 683-700. 10.1007/s00726-012-1392-x.

    CAS  PubMed  Google Scholar 

  12. Buchanan RL, Ocker LA, Stahl HG: Effect of 2-deoxyglucose, alpha-methylglucoside, and glucosamine on aflatoxin production by Aspergillus parasiticus. Arch Microbiol. 1985, 142 (2): 200-203. 10.1007/BF00447068.

    CAS  PubMed  Google Scholar 

  13. Chenault HK, Mandes RF: Selective inhibition of metabolic enzymes by enzymatically synthesized D-glucal-6-phosphate. Bioorg Med Chem. 1994, 2 (7): 627-629. 10.1016/0968-0896(94)85010-0.

    CAS  PubMed  Google Scholar 

  14. Rogers MJ, Brandt KG: Multiple inhibition analysis of Aspergillus niger glucose oxidase by D-glucal and halide ions. Biochemistry. 1971, 10 (25): 4636-4641. 10.1021/bi00801a007.

    CAS  PubMed  Google Scholar 

  15. Rogers MJ, Brandt KG: Interaction of D-glucal with Aspergillus niger glucose oxidase. Biochemistry. 1971, 10 (25): 4624-4630. 10.1021/bi00801a005.

    CAS  PubMed  Google Scholar 

  16. Lee YC: Inhibition of beta-D-galactosidases by D-galactal. Biochem Biophys Res Commun. 1969, 35 (1): 161-167. 10.1016/0006-291X(69)90499-9.

    CAS  PubMed  Google Scholar 

  17. Adye J, Mateles RI: Incorporation of labelled compounds into aflatoxins. Biochim Biophys Acta. 1964, 86 (2): 418-420. 10.1016/0304-4165(64)90077-7.

    CAS  PubMed  Google Scholar 

  18. Yan SJ, Liang YT, Zhang JD, Liu CM: Aspergillus flavus grown in peptone as the carbon source exhibits spore density- and peptone concentration-dependent aflatoxin biosynthesis. BMC Microbiol. 2012, 12: 106-10.1186/1471-2180-12-106.

    PubMed Central  CAS  PubMed  Google Scholar 

  19. Bentley R: Preparation and analysis of kojic acid. Method Enzymol. 1957, 3: 238-241.

    Google Scholar 

  20. Papa KE: Genetics of Aspergillus flavus: linkage of aflatoxin mutants. Can J Microbiol. 1984, 30 (1): 68-73. 10.1139/m84-012.

    CAS  PubMed  Google Scholar 

  21. Feng GH, Leonard TJ: Characterization of the polyketide synthase gene (pksL1) required for aflatoxin biosynthesis in Aspergillus parasiticus. J Bacteriol. 1995, 177 (21): 6246-6254.

    PubMed Central  CAS  PubMed  Google Scholar 

  22. Ehrlich KC, Scharfenstein LL, Montalbano BG, Chang PK: Are the genes nadA and norB involved in formation of aflatoxin G1?. Int J Mol Sci. 2008, 9 (9): 1717-1729. 10.3390/ijms9091717.

    PubMed Central  CAS  PubMed  Google Scholar 

  23. Cai J, Zeng H, Shima Y, Hatabayashi H, Nakagawa H, Ito Y, Adachi Y, Nakajima H, Yabe K: Involvement of the nadA gene in formation of G-group aflatoxins in Aspergillus parasiticus. Fungal Genet Biol. 2008, 45 (7): 1081-1093. 10.1016/j.fgb.2008.03.003.

    CAS  PubMed  Google Scholar 

  24. Terabayashi Y, Sano M, Yamane N, Marui J, Tamano K, Sagara J, Dohmoto M, Oda K, Ohshima E, Tachibana K, Higa Y, Ohashi S, Koike H, Machida M: Identification and characterization of genes responsible for biosynthesis of kojic acid, an industrially important compound from Aspergillus oryzae. Fungal Genet Biol. 2010, 47 (12): 953-961. 10.1016/j.fgb.2010.08.014.

    CAS  PubMed  Google Scholar 

  25. Buchanan RL, Stahl HG: Ability of various carbon-sources to induce and support aflatoxin synthesis by Aspergillus parasiticus. J Food Safety. 1984, 6: 271-279. 10.1111/j.1745-4565.1984.tb00488.x.

    CAS  Google Scholar 

  26. Tyagi JS, Venkitasubramanian TA: The role of glycolysis in aflatoxin biosynthesis. Can J Microbiol. 1981, 27 (12): 1276-1282. 10.1139/m81-196.

    CAS  PubMed  Google Scholar 

  27. Shantha T, Murthy VS: Influence of tricarboxylic acid cycle intermediates and related metabolites on the biosynthesis of aflatoxin by resting cells of Aspergillus flavus. Appl Environ Microbiol. 1981, 42 (5): 758-761.

    PubMed Central  CAS  PubMed  Google Scholar 

  28. Rolland F, Winderickx J, Thevelein JM: Glucose-sensing and -signalling mechanisms in yeast. Fems Yeast Res. 2002, 2 (2): 183-201. 10.1111/j.1567-1364.2002.tb00084.x.

    CAS  PubMed  Google Scholar 

  29. Marui J, Yamane N, Ohashi-Kunihiro S, Ando T, Terabayashi Y, Sano M, Ohashi S, Ohshima E, Tachibana K, Higa Y, Nishimura M, Koike H, Machida M: Kojic acid biosynthesis in Aspergillus oryzae is regulated by a Zn(II)(2)Cys(6) transcriptional activator and induced by kojic acid at the transcriptional level. J Biosci Bioeng. 2011, 112 (1): 40-43. 10.1016/j.jbiosc.2011.03.010.

    CAS  PubMed  Google Scholar 

  30. Yu JJ, Fedorova ND, Montalbano BG, Bhatnagar D, Cleveland TE, Bennett JW, Nierman WC: Tight control of mycotoxin biosynthesis gene expression in Aspergillus flavus by temperature as revealed by RNA-Seq. Fems Microbiol Lett. 2011, 322 (2): 145-149. 10.1111/j.1574-6968.2011.02345.x.

    CAS  PubMed  Google Scholar 

  31. Pegg AE, Poulin R, Coward JK: Use of aminopropyltransferase inhibitors and of non-metabolizable analogs to study polyamine regulation and function. Int J Biochem Cell Biol. 1995, 27 (5): 425-442. 10.1016/1357-2725(95)00007-C.

    CAS  PubMed  Google Scholar 

  32. Buchanan RL, Federowicz D, Stahl HG: Activities of tricarboxylic-acid cycle enzymes in an aflatoxigenic strain of Aspergillus parasiticus after a peptone to glucose carbon source shift. T Brit Mycol Soc. 1985, 84 (Mar): 267-275.

    CAS  Google Scholar 

  33. Maggon KK, Gupta SK, Venkitasubramanian TA: Biosynthesis of aflatoxins. Bacteriol Rev. 1977, 41 (4): 822-855.

    PubMed Central  CAS  PubMed  Google Scholar 

  34. Arnstein HR, Bentley R: The biosynthesis of kojic acid. I. Production from (1-14C) and (3:4-14C2) glucose and (2-14C)-1:3-dihydroxyacetone. Biochem J. 1953, 54 (3): 493-508.

    PubMed Central  CAS  PubMed  Google Scholar 

  35. Gomes AJ, Lunardi CN, Gonzalez S, Tedesco AC: The antioxidant action of polypodium leucotomos extract and kojic acid: reactions with reactive oxygen species. Braz J Med Biol Res. 2001, 34 (11): 1487-1494.

    CAS  PubMed  Google Scholar 

  36. Jayashree T, Subramanyam C: Oxidative stress as a prerequisite for aflatoxin production by Aspergillus parasiticus. Free Radic Biol Med. 2000, 29 (10): 981-985. 10.1016/S0891-5849(00)00398-1.

    CAS  PubMed  Google Scholar 

  37. Jayashree T, Subramanyam C: Antiaflatoxigenic activity of eugenol is due to inhibition of lipid peroxidation. Lett Appl Microbiol. 1999, 28 (3): 179-183. 10.1046/j.1365-2672.1999.00512.x.

    CAS  PubMed  Google Scholar 

  38. Kim JH, Yu JJ, Mahoney N, Chan KL, Molyneux RJ, Varga J, Bhatnagar D, Cleveland TE, Nierman WC, Campbell BC: Elucidation of the functional genomics of antioxidant-based inhibition of aflatoxin biosynthesis. Int J Food Microbiol. 2008, 122 (1–2): 49-60.

    CAS  PubMed  Google Scholar 

  39. Tzanidi C, Proestos C, Markaki P: Saffron (Crocus sativus L.) inhibits aflatoxin B1 production by Aspergillus parasiticus. Adv Microbiol. 2012, 2 (3): 310-316. 10.4236/aim.2012.23037.

    Google Scholar 

  40. Yoshinari T, Akiyama T, Nakamura K, Kondo T, Takahashi Y, Muraoka Y, Nonomura Y, Nagasawa H, Sakuda S: Dioctatin A is a strong inhibitor of aflatoxin production by Aspergillus parasiticus. Microbiology. 2007, 153 (8): 2774-2780. 10.1099/mic.0.2006/005629-0.

    CAS  PubMed  Google Scholar 

  41. Basappa SC, Sreenivasamurthy V, Parpia HA: Aflatoxin and kojic acid production by resting cells of Aspergillus flavus Link. J Gen Microbiol. 1970, 61 (1): 81-86. 10.1099/00221287-61-1-81.

    CAS  PubMed  Google Scholar 

  42. Sekiguchi J, Gaucher GM: Conidiogenesis and secondary metabolim in Penicillium urticae. Appl Environ Microbiol. 1977, 33 (1): 147-158.

    PubMed Central  CAS  PubMed  Google Scholar 

  43. GuzmandePena D, RuizHerrera J: Relationship between aflatoxin biosynthesis and sporulation in Aspergillus parasiticus. Fungal Genet Biol. 1997, 21 (2): 198-205. 10.1006/fgbi.1996.0945.

    CAS  Google Scholar 

  44. Hicks JK, Yu JH, Keller NP, Adams TH: Aspergillus sporulation and mycotoxin production both require inactivation of the FadA G alpha protein-dependent signaling pathway. EMBO J. 1997, 16 (16): 4916-4923. 10.1093/emboj/16.16.4916.

    PubMed Central  CAS  PubMed  Google Scholar 

  45. Chang PK, Hua SS: Molasses supplementation promotes conidiation but suppresses aflatoxin production by small sclerotial Aspergillus flavus. Lett Appl Microbiol. 2007, 44 (2): 131-137. 10.1111/j.1472-765X.2006.02056.x.

    CAS  PubMed  Google Scholar 

  46. Keller NP, Nesbitt C, Sarr B, Phillips TD, Burow GB: pH regulation of sterigmatocystin and aflatoxin biosynthesis in Aspergillus spp. Phytopathology. 1997, 87 (6): 643-648. 10.1094/PHYTO.1997.87.6.643.

    CAS  PubMed  Google Scholar 

Download references

Acknowledgments

The authors thank Fen Yang for early protocol development, and Lixin Duan and Zhen Xue at the Key Laboratory of Molecular Plant Physiology, CAS, for technical assistance. This research was supported by the Key Innovation Project (KSCX2-YW-N-033) and 100-Talent Project of the Chinese Academy of Sciences, granted to CML.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Chun-Ming Liu.

Additional information

Competing interests

The authors declare that they have no competing interests.

Authors’ contributions

JDZ designed and performed the experiments; JDZ and LDH analyzed the data; SJY helped to develop some analysis tools; JDZ and CML wrote the manuscript. All authors read and approved the final manuscript.

Electronic supplementary material

Authors’ original submitted files for images

Rights and permissions

Open Access This article is published under license to BioMed Central Ltd. This is an Open Access article is distributed under the terms of the Creative Commons Attribution License ( https://creativecommons.org/licenses/by/2.0 ), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly credited. The Creative Commons Public Domain Dedication waiver ( https://creativecommons.org/publicdomain/zero/1.0/ ) applies to the data made available in this article, unless otherwise stated.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Zhang, JD., Han, L., Yan, S. et al. The non-metabolizable glucose analog D-glucal inhibits aflatoxin biosynthesis and promotes kojic acid production in Aspergillus flavus . BMC Microbiol 14, 95 (2014). https://doi.org/10.1186/1471-2180-14-95

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/1471-2180-14-95

Keywords